![]() O Light bulbs are teflon-coated (rough service). ![]() O Electrical cords are intact and have grounding prongs. O Lifts have operable safety locks, and are tested and serviced monthly. O There are no illegal furnaces or space heaters in use. O Waste oil furnaces are permitted by appropriate state agency or local fire department (as required). O Underground storage tank and above-ground storage tanks are permitted by appropriate state agency or local fire department (as required). O Floors are made of noncombustible material, free of oil and grease, and sealed. O There are no cracks in the floor that would allow leakage. O Floor drains are connected to the sewer (with approval from sewer authority) or equipped with an approved oil-water separator or tight tank. O There is adequate central ventilation and adequate local ventilation for carbon monoxide from tailpipe exhaust systems. O Wiring is enclosed in Electrical Metallic Tubing (EMT) or rigid No wires are frayed, damaged, or taped off. Access to the circuit box is clear within 5-10 feet. O Circuits are labeled and the circuit box is closed. O Electrical receptacles have no open grounds or reverse polarity. O Smoking is prohibited where the repair work is done and allowed only in designated areas. O Aisles and emergency exits are clear, and exit signs are posted O Signs are posted over each extinguisher. O Employees have been trained in the use of fire extinguishers. (Additional extinguishers may be necessary if the building is made of combustible materials.) O A 40BC fire extinguisher is available, with 10BC extinguishers positioned every 50 feet. O All openings in walls and ceilings are sealed. O Fire doors are equipped with automatic closures. O Building has two-hour firewalls (two walls of sheetrock or masonry) between repair garage and attached structures. O Drums of materials and wastes stored outside of the building have secondary containment (e.g., berms). O There are no leaks or excessive spillage in chemical or waste storage areas, including around solvent sinks, pumps, pipes, hoses, couplings, fittings, and valves. O Flammable liquids are grounded and bonded during transfer, and grounded during storage. O Waste storage area is labeled and limits of area are marked. O Flammables are stored in an area (such as an air-tight metalĬabinet, metal cabinet vented to the outside, or flammables storage room) approved by the local fire department. O Containers, tanks, and flammables cabinets are labeled with the name of the material they hold (for example, waste oil) and the type of hazard they present (e.g., flammable). O Lids are tight-fitting and sealed, and bungs are closed. Department of Transportation or by the State Fire Marshall, or listed and labeled by the National Registration and Testing Laboratory (UL-listed). ![]() O Flammable and hazardous liquids are stored in containers that are either approved by the US. (Including oils, solvents, antifreeze and gasoline) Section A : G e n e r a l W a l k - T h r o u g h o f S i t eġ. While not required by law, following these practices helps to reduce compliance costs and ensure the well-being of employees.Ĭheck only those items that require remedial action. Section C provides space to comment on any deficiencies observed during an inspection.Īlso included with this compliance checklist is a list of tips for preventing pollution, fires, and health and safety hazards. The regulatory items listed on this form fall into two main categories: those in Section A relate to overall conditions at the site those in Section B cover specific auto repair shop operations. While the checklist includes the primary concerns of regulatory inspections, it is not intended to be a comprehensive statement of compliance requirements. The requirements listed here are based on federal environmental and health and safety regulations, as well as nationally recognized fire code. Municipal health, fire prevention, and building inspectors may also find it useful for preliminary screening and for assisting shops. This self-audit tool is designed to help auto repair shop owners achieve and maintain regulatory compliance.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |